Plant Soil Environ., 2025, 71(2):109-122 | DOI: 10.17221/197/2024-PSE

On-site composting of waste hop biomass: the impact of covering piles on leachate quantity and compost qualityOriginal Paper

Barbara Čeh ORCID...1, Julija Polanšek2, Žan Trošt1, Ana Karničnik Klančnik1
1 Slovenian Institute of Hop Research and Brewing, Žalec, Slovenia
2 Agricultural Institute of Slovenia, Ljubljana, Slovenia

Covering hop waste composting piles with semipermeable membrane after the thermophilic phase until spring, when the compost was ready to use, reduced the volume of leachate and leached nutrients amounts significantly; there was a negligible amount of leachate and low amount of leached nutrients during winter and spring at all treatments. At treatments with additives (biochar, preparation effective microorganisms) and larger percent of particles of 2–5 cm, it was indicated that composting pile should probably also be covered in the first months of composting and be opened only when turning/mixing it; on the other hand, the amount of leachate was much lower in a pile without additives and particles of 2–10 cm by the time of covering (2.2- and 2.5-fold less respectively) and the amount of leached nutrients as well. All treatments produced compost without a bad smell, had a total nitrogen content greater than 2%, could be considered as mature (the C : N ratio was below 20) and stable, and the biomass hygienisation threshold was reached. However, there were some significant differences among them. The compost of the pile with added biochar and starting hop waste biomass particles of 2–5 cm was considered phytotoxic (germination index of radish was 31%); also, its other results were less promising in comparison to other treatments. The pile with no additive and the starting particles of waste hop biomass 2 to 10 cm, mixed properly related to regular temperature measurements in the thermophilic phase, reached the best results; the leachate amount and leaked nutrients amount were significantly the lowest, while the final compost contained significantly higher amount of nutrients and had the highest germination index.

Keywords: Humulus lupulus L.; on-farm composting; environment protection; leachate; circular economy on farms; organic matter; waste management; recycling; soil fertility; germination test; respiratory test; bacteria and fungi

Received: April 26, 2024; Revised: August 7, 2024; Accepted: August 20, 2024; Prepublished online: February 5, 2025; Published: February 24, 2025  Show citation

ACS AIP APA ASA Harvard Chicago Chicago Notes IEEE ISO690 MLA NLM Turabian Vancouver
Čeh B, Polanšek J, Trošt Ž, Karničnik Klančnik A. On-site composting of waste hop biomass: the impact of covering piles on leachate quantity and compost quality. Plant Soil Environ. 2025;71(2):109-122. doi: 10.17221/197/2024-PSE.
Share...
Download citation
  • BibTeX (.bib)
  • Bookends (.ris)
  • EasyBib (.ris)
  • EndNote (.enw)
  • EndNote 8 (.xml)
  • ISI WoS (.isi)
  • Medlars (.medlars)
  • Mendeley (.ris)
  • MODS (.xml)
  • Papers (.ris)
  • RefWorks (.txt)
  • RefManager (.ris)
  • RIS (.ris)
  • MS Word (.xml)
  • Zotero (.ris)
    • Open full article

    References

    1. AGROMET (2024): Agrometeorological Portal of Slovenia. Available at: http://agromet.mkgp.gov.si/APP/Tag/Export/164 (accessed on 12 March 2024).
    2. Ainali N.M., Kalaronis D., Evgenidou E., Kyzas G.Z., Bobori D.C., Kaloyianni M., Yang X., Bikiaris D.N., Lambropoulou D.A. (2022): Do poly(lactic acid) microplastics instigate a threat? A perception of their dynamic towards environmental pollution and toxicity. Science of The Total Environment, 832: 155014. Go to original source... Go to PubMed...
    3. Al-Bataina B.B., Young T.M., Ranieri E. (2016): Effects of compost age on the release of nutrients. International Soil and Water Conservation Research, 4: 230-236. Go to original source...
    4. Amatya I.M., Kansakar B.R., Tare V., Fiksdal L. (2011): Role of pH on biological nitrification process. Journal of the Institute of Engineering, 31: 1180-1186.
    5. Babnik D., Žnidaršič Pongrac V., Kmecl V., Sušin J., Verbič J., Šegula B., Jeretina J. (2006): The composition of livestock manures in Slovenia. In: Kapun S., Čeh T. (eds.): Proceedings of the 15th Conference on Animal Nutrition, 15: 272-283.
    6. Bary A., Cogger C., Sullivan D. (2016): Fertilizing with Manure and Other Organic Amendments. Pullman, Pacific Northwest Extension Publications.
    7. Boawn L. (1965): Zinc concentration in hop leaves in relation to adequate and inadequate levels of zinc nutrition. Agronomy Journal, 57: 523-524. Go to original source...
    8. Chowdhury A.K.M.M.B., Akratos C.S., Vayenas D.V., Pavlou S. (2013): Olive mill waste composting: a review. International Biodeterioration and Biodegradation, 85: 108-119. Go to original source...
    9. Confesor R.B., Hamlett J.M., Shannon R.D., Graves R.E. (2009): Potential pollutants from farm, food and yard waste compost at differing ages: leaching potential of nutrients under column experiments. Part II. Compost Science and Utilization, 17: 6-17. Go to original source...
    10. Čeh B., Luskar L., Čremožnik B. (2019): Hop biomass after harvest as input material for composting. Hop Bulletin, 26: 81-90.
    11. Čeh B., Luskar L., Polanšek J., Karničnik Klančnik A., Trošt Ž. (2023): Increasing the value of waste hop biomass by composting: closing the nutrient cycle on hop farms. In: Khalid R.H. (ed.): Organic Fertilizers - New Advances and Applications. IntechOpen. Available at: https://doi.org/10.5772/intechopen.1001340. Go to original source...
    12. Čeh B., Luskar L., Hladnik A., Trošt Ž., Polanšek J., Naglič B. (2022b): The quantity and composition of leachate from hop plant biomass during the composting process. Applied Sciences, 12: 2375. Go to original source...
    13. EPA (2024): U.S. Environmental Protection Agency. Available at: https://www.epa.gov/sustainable-management-food/approaches-composting (accessed on 19 April 2024)
    14. European Commission (2001): Biological Treatment of Biowaste. Working Document. Available at: http://www.cre.ie/docs/EU_BiowasteDirective_workingdocument_2nddraft.pdf (accessed on 7 December 2021)
    15. Grigoras A.G. (2021): Natural and synthetic polymeric antimicrobials with quaternary ammonium moieties: a review. Environmental Chemistry Letters, 19: 3009-3022. Go to original source...
    16. Hodnik A. (1988): Chemical Analysis of Soil Samples, Plant Samples and Drainage Water. Ljubljana, Biotechnical Faculty, Department of Pedology, Plant Nutrition, and Ecology, 92.
    17. Jackson M.L. (1958): Soil Chemical Analysis. Englewood Cliffs, Prentice Hall, Inc., 498.
    18. Jahangir M.M.R., Islam S., Nitu T.T., Uddin S., Kabir A.K.M.A., Meah M.B., Islam R. (2021): Bio-compost-based integrated soil fertility management improves postharvest soil structural and elemental quality in a two-year conservation agriculture practice. Agronomy, 11: 11. Go to original source...
    19. Karamanlioglu M., Robson G.D. (2013): The influence of biotic and abiotic factors on the rate of degradation of poly (lactic) acid (PLA) coupons buried in compost and soil. Polymer Degradation and Stability, 98: 2063-2071. Go to original source...
    20. Kaurin A., Gluhar S., Tilikj N., Lestan D. (2020): Soil washing with biodegradable chelating agents and EDTA: effect on soil properties and plant growth. Chemosphere, 260: 127673. Go to original source... Go to PubMed...
    21. Key L. (2012): How to prepare a beneficial microorganism mixture. Channon, Permaculture Research Insitute. Available at: https://www.permaculturenews.org/2012/02/04/how-to-prepare-a-beneficial-microorganism-mixture/
    22. Luskar L., Polanšek J., Hladnik A., Čeh B. (2022): On-farm composting of hop plant green waste - chemical and biological value of compost. Applied Sciences, 12: 4190. Go to original source...
    23. Maniadakis K., Lasaridi K., Manios Y., Kyriacou M., Manios T. (2004): Integrated waste management through producers and consumers education: composting of vegetable crop residues for reuse in cultivation. Journal of Environmental Science and Health, Part B, 39: 169-183. Go to original source... Go to PubMed...
    24. McFarland M.J. (2001): Biosolids Engineering. New York, McGraw-Hill Education.
    25. Milinković M., Lalević B., Jovičić-Petrović J., Golubović-Ćurguz V., Kljujev I., Raičević V. (2019): Biopotential of compost and compost products derived from horticultural waste - effect on plant growth and plant pathogens' suppression. Process Safety and Environmental Protection, 121: 299-306. Go to original source...
    26. Oshins C., Michel F., Louis P., Richard T.L., Rynk R. (2022): The composting process. In: The Composting Handbook. San Diego, Academic Press, 51-101 Go to original source...
    27. Pan C., Zhao Y., Chen X., Zhang G., Xie L., Wei Z., Song C. (2023): Improved carbon sequestration by utilization of ferrous ions during different organic wastes composting. Journal of Environmental Management, 347: 119188. Go to original source... Go to PubMed...
    28. Pirsaheb M., Amini J., Hossaini H. (2021): Application of ABR/zeolite for TKN removal from compost leachate. Environmental Technology and Innovation, 24: 102020. Go to original source...
    29. Regulation on the Recovery of Biodegradable Waste and the Use of Compost or Digestate (2013): Official Gazette of the Republic of Slovenia, No. 99/13. Available at: http://www.pisrs.si/Pis.web/pregledPredpisa?id=URED6281 (accessed on 14 April 2024) (In Slovene)
    30. Regulatory Services, Clemson University (2024): Available at: Compost Interpretation|Public | Clemson University, South Carolina.
    31. Romero C., Ramos P., Costa C., Márquez M.C. (2013): Raw and digested municipal waste compost leachate as potential fertilizer: comparison with a commercial fertilizer. Journal of Cleaner Production, 59: 73-78. Go to original source...
    32. Roy D., Azaïs A., Benkaraache S., Drogui P., Tyagi R.D. (2018): Composting leachate: characterization, treatment, and future perspectives. Reviews in Environmental Science and Bio/Technology, 17: 323-349. Go to original source...
    33. Tamás A., Vrânceanu N., Dusa M., Stan V. (2019): Steps in organic fraction of municipal solid waste composting and compost quality evaluation. Scientific Papers Series A. Agronomy, 2: 144-153.
    34. Tencate Toptex. Compost cover tarp. Available at: https://shopamine-products.s3.amazonaws.com/products/17012/Kompost_SLO.pdf
    35. USDA N. (1999): United States Department of Agriculture. Natural Resources Conservation Service. Plants Database. Available at: http://plants. usda. gov (accessed in 2002)
    36. Van der Wurff A.W.G., Fuchs J.G., Raviv M., Termorshuizen A.J. (2016): Handbook for Composting and Compost Use in Organic Horticulture. BioGreenhouse COST Action FA1105, 108. Go to original source...
    37. Wang Y., Tang Y., Li M., Yuan Z. (2021): Aeration rate improves the compost quality of food waste and promotes the decomposition of toxic materials in leachate by changing the bacterial community. Bioresource Technology, 340: 125716. Go to original source... Go to PubMed...
    38. Warman P.R. (1999): Evaluation of seed germination and growth tests for assessing compost maturity. Compost Science and Utilization, 7: 33-37. Go to original source...
    39. Zucconi F. (1981): Evaluating toxicity of immature compost. Biocycl, 22: 54-57.
    40. Zucconi F., De Bertoldi M. (1987): Compost specifications for the production and characterization of compost from municipal solid waste. In: De Bertoldi M., Ferranti M.P., L'Hermite P., Zucconi F. (eds): Compost: Production, Quality and Use. London, Elsevier Applied Science, 30-50.

    This is an open access article distributed under the terms of the Creative Commons Attribution-NonCommercial 4.0 International (CC BY NC 4.0), which permits non-comercial use, distribution, and reproduction in any medium, provided the original publication is properly cited. No use, distribution or reproduction is permitted which does not comply with these terms.


    Return to the content